Bus Solar Panel Mounting

Troy dickens whitewhaleskoolie tilt concept mounting solar panels in a stationary location such as on the roof of a house or in a field is fairly straightforward.

Bus solar panel mounting.

Due to the natural curve of a school bus roof when the panels are in the down position each array sits at a slight angle in opposite directions. Solarworld s five busbar 60 cell panels have approached the nameplate power of competitors 72 cell presumably three or four busbar panels. In this video you will learn some of the best ways to mount your panels regardless of what camper van or school bus you are in. Solar panel mounting and installation tips for school bus conversions.

Wattsun only recommended for large scale commercial installs a solar panel mount or solar racking system is the foundation that holds your solar array in place. Mounting a solar panel in this fashion subjects the solar panel to wind thus potentially stressing the panel mounts and wiring. You ll first mount the solar panels attach the controller and batteries then theft proof the rover. Utilizing a unistrut is key to this installation.

One of our favorite systems is 2 4x 170w solar panels on an 85a charge controller. The easy way to decide what size of charge controller you need is to divide the input wattage by the system voltage and multiply by 1 2 for safety if you have 400 watts of solar panels charging a 12 volt system 400 12 you get 33 33 amps. Folding solar panel blueprint. My installation drops the solar panels below an attachment bar unistrut and only two to three inches above the existing roof rack.

200 watts on 12 volts x1 2 20 amps. The panels are mounted to hinges along the center of the roof and secured to brackets with finger nuts at the outer edge of the roof. This gives you room to add more panels in the future if you find you need more energy. Select solar charging system.

The panels themselves can take much higher wind speeds but it s all in how you mount them to the roof. Here in the northern hemisphere the basic concept for stationary panels is to tilt them toward the south at a certain angle relative. This builder says this system is used to power many outdoor events on a school campus so you could consider downsizing if this is just for your own home. Mounting solar panels to the roof of a van most solar panels are designed to sit on the roof of a house not to be driving down the road at 70 miles per hour.

Multiply by 1 2 and you need a 40 amp charge controller. Solarworld s new solar panels use passivated emitter reach cell perc technology and two additional busbars to boost power by 2 and increase efficiency. Mounting your solar panels can be difficult.